Instruction/ maintenance manual of the product V36N-A Desa
Go to page of 40
FOR YOUR SAFETY WHAT TO DO IF YOU SMELL GAS • Do not try to light any appliance. • Do not touch any electrical switch • Do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 2 SAFETY INFORMA TION WARNING: This product contains and/or generates chemicals known to the State of California to cause cancer or birth defects, or other reproductive harm.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 3 3 SAFETY INFORMA TION Continued PRODUCT IDENTIFICA TION Figure 1 - Direct-Vent Fireplace with Mil.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 4 PRODUCT FEA TURES These are a few facts that can help you understand and enjoy your direct-vent fireplace: • The venting system may be routed to the outside of your home in several ways.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 5 5 A B E F G H D C Nailing T abs CLEARANCES Minimum clearances to combustibles for the fireplace a.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 6 Fixed Closed Openable Fixed Closed Openable V V V V V V V V X X V X G G J F B B K N H I A N E L D.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 7 7 VENTING INST ALLA TION INSTRUCTIONS NOTICE: Read these instructions completely be- fore attempting installation. These models are tested and approved for use with DESA (direct- vent) pipe components and terminations.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 8 INSTALLATION PLANNING There are two basic types of direct-vent installation: • Horizontal T erm.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 9 9 WARNING: Do not recess vent termination into any wall.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 10 Horizontal High Wind Square Termination Wall Firestop 45° Elbow Figure 14 - Horizontal Terminat.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 11 11 Figure 15 - Horizontal Termination Configuration for Corner Installation Using One 90° Elbow.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 12 V enting with T wo 90° Elbows V er tical (V) Horizontal (H 1 ) + Horizontal (H 2 ) 5' min. 6' max. 6' min. 12' max. 7' min.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 13 13 INSTALLATION FOR VERTICAL TERMINATION Note: Vertical restrictor must be installed in all vertical installations. 1. Determine the route your vertical venting will take.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 14 VENTING INST ALLA TION INSTRUCTIONS Continued Vertical Termination Configurations Figures 21 through 24 show four different configurations for verti- cal termination.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 15 15 VENTING INST ALLA TION INSTRUCTIONS Continued V ertical V enting V = 40' max.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 16 FIREPLACE INST ALLA TION CHECK GAS TYPE Use proper gas type for the fireplace unit you are installing. If you have conflicting gas types, do not install fireplace.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 17 17 . FIREPLACE INSTALLATION Installing Optional Blower Accessories (Cont.) V a r ia bl e F a n S w it c h W h it e W h i te B la c k G re e n O n 1 1 0 /1 1 5 V .
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 18 INSTALLING GAS PIPING TO FIREPLACE LOCATION Installation Items Needed Before installing fireplace, make sure you have the items listed below.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 19 19 FIREPLACE INST ALLA TION Continued FIREPLACE INSTALLATION Installing Gas Piping to Fireplace Location (Cont.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 20 Figure 33 - Equipment Shutoff Valve Open Closed Equipment Shutoff Valve Figure 35 - Checking Gas.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 21 21 FIREPLACE INST ALLA TION Continued FIREPLACE INSTALLATION Installing Optional Wireless Hand-Held Remote Control - (C)GHRCB and (C)GHRCTB Series Installing Remote Receiver 1.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 22 Lock Unlock REMOVING/REPLACING GLASS DOOR CAUTION: Do not operate this fireplace with a broken glass door panel or without the glass door panel securely in place.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 23 23 FIREPLACE INST ALLA TION Continued FIREPLACE INSTALLATION Installing Optional Brick Liner Mod.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 24 WARNING: The glass door must be securely in place before running this fireplace. Do not run this fireplace if glass is missing or broken. NOTICE: Do not put lava rock on burner or under burner.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 25 25 OPERA TING FIREPLACE LIGHTING INSTRUCTIONS 1 . ST OP! Read the safety information above. 2. Open lower louver panel. 3. T urn off all electric power to the fir eplace.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 26 OPERA TING FIREPLACE Continued OPERATING FIREPLACE Optional Hand-Held Remote Operation O F F P I.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 27 27 OPERATING FIREPLACE Optional Hand-Held Remote Operation (Cont.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 28 INSPECTING BURNERS Burner Flame Pattern CLEANING AND MAINTENANCE Glass Door Pilot and Burners Logs Venting System PILOT AND BURNERS • Remove ember material before cleaning burners and replace when cleaning is complete.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 29 29 TROUBLESHOOTING TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. WARNING: Turn off heater and let cool before servicing.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 30 OBSERVED PROBLEM Burner does not light after pilot is lit Delayed ignition burner Burner backfir.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 31 31 TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 32 ILLUSTRATED PARTS BREAKDOWN Models V36N-A, V36P-A, VV36NB(1), VV36NSB(1), VV36NHB(1), VV36PB(1),.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 33 33 PARTS LIST Models V36N-A, V36P-A, VV36NB(1), VV36NSB(1), VV36NHB(1), VV36PB(1), VV36PSB(1), VV36PHB(1) and CHDV36NR-B P ARTS LIST This list contains replaceable parts used in your fireplace.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 34 4 3 2 5 6 7 8 9 10 11 12 13 14 15 16 17 1 21 19 20 18 ILLUSTRA TED P AR TS BREAKDOWN BURNER ASSE.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 35 35 KEY PART NO. NUMBER DESCRIPTION QTY. 1 ** Burner Assembly Base 1 2 108759-01 Pan Burner Assem.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 36 V36N-A V36P-A VV36N B(1) CHDV36NR-B VV36P B(1) Btu 18,000/ 18,000/ 17,500/ 26,000 Btu/hr 26,000 Btu/hr 25,000 Btu/hr Gas Type Natural Natural Propane/LP Ignition Piezo Piezo Piezo Manifold Pressure 3.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 37 37 1. Where will the product be used? ❍ Living/F amily Room ❍ Office/Warehouse ❍ Utility Shed/Outb uilding ❍ Garage ❍ Bedroom ❍ Bathroom ❍ Other 2.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 38 2701 Industrial Drive P.O. Box 90004 Bowling Green, KY 42102-9004 Postage Required T APE T APE.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 39 39 ACCESSORIES Purchase these fireplace accessories from your local retailer. If they can not supply these accessories, call DESA’s Sales Department at 1-866-672-6040.
111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 40 LIMITED WARRANTY DIRECT-VENT FIREPLACE DESA warrants this product to be free from defects in mat.
An important point after buying a device Desa V36N-A (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Desa V36N-A yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Desa V36N-A - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Desa V36N-A you will learn all the available features of the product, as well as information on its operation. The information that you get Desa V36N-A will certainly help you make a decision on the purchase.
If you already are a holder of Desa V36N-A, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Desa V36N-A.
However, one of the most important roles played by the user manual is to help in solving problems with Desa V36N-A. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Desa V36N-A along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
