Instruction/ maintenance manual of the product CSDV30SLP Monessen Hearth
Go to page of 44
.
2 58D6056 CSD V Se ries Direct V e nt Gas Sto ve .
58D6056 3 CSD V Se ries Direct V e nt Gas Sto ve 4. Never install the stove • in a recreational vehicle • where curtains, furniture, clothing, or other flam- mable objects are less than 42" from the front, top, or sides of the stove • in high traffic areas • in windy or drafty areas 5.
4 58D6056 CSD V Se ries Direct V e nt Gas Sto ve 15. This appliance, when installed, must be electrically grounde.
58D6056 5 CSD V Se ries Direct V e nt Gas Sto ve • This appliance has been certified for use with either natural or propane gas.
6 58D6056 CSD V Se ries Direct V e nt Gas Sto ve A B C 586056 CSDV dims .
58D6056 7 CSD V Se ries Direct V e nt Gas Sto ve Plan for the installation of your stove.
8 58D6056 CSD V Se ries Direct V e nt Gas Sto ve .
58D6056 9 CSD V Se ries Direct V e nt Gas Sto ve ON OFF A C B ST1 132 alcove clearances Figure 5 - Alco.
10 58D6056 CSD V Se ries Direct V e nt Gas Sto ve 1. Remove two (2) straps. Figure 6 2. Open plastic bag and slide to bottom of unit. Figure 7 3. Lift up on ash lip and pivot down to open control door . Figure 8 4. Lift up on front. Pivot bottom of front out.
58D6056 1 1 CSD V Se ries Direct V e nt Gas Sto ve .
12 58D6056 CSD V Se ries Direct V e nt Gas Sto ve There are two b.
58D6056 13 CSD V Se ries Direct V e nt Gas Sto ve V V V V V V V X X X D E B B B C B M B A J K F L VENT TERMINA TION AIR SUPPL Y INLET AREA WHERE TERMINAL IS NOT PERMITTED H I Fixed Closed Operable Operable Fixed Closed V B CFM145a DV T ermin Location 5/01/01 Rev .
14 58D6056 CSD V Se ries Direct V e nt Gas Sto ve Outside Corner Inside Corner T ermination Clearances T ermination clearances for buildings with combustible and noncombustible exteriors.
58D6056 15 CSD V Se ries Direct V e nt Gas Sto ve 1. Determine the route your horizontal venting will take.
16 58D6056 CSD V Se ries Direct V e nt Gas Sto ve 9 Zx " (241 mm) 9 Zx " (241 mm) .
58D6056 17 CSD V Se ries Direct V e nt Gas Sto ve HOT H V ST1 139 Horizontal termination Figure 21 - Horizontal T ermination Configura.
18 58D6056 CSD V Se ries Direct V e nt Gas Sto ve HOT H 1 V 1 H V ST1 141 Horiz term 3 elbows Figure 23 - Horizontal T ermination Conf.
58D6056 19 CSD V Se ries Direct V e nt Gas Sto ve Drop a plumb line from the inside of the roof to the locat- ing hole in the ceiling. Mark the center point where the vent will penetrate the roof.
20 58D6056 CSD V Se ries Direct V e nt Gas Sto ve 3. Lower the support box through the hole in the roof until the bottom of the box extends at least 2" ( mm) below the ceiling. Figure 27. Align the support box vertically and horizontally using a level.
58D6056 21 CSD V Se ries Direct V e nt Gas Sto ve H V V 1 ST1 146 vert vent 2 elbows Install restrictor into 4" collar of stove or f i r s t v e nt s e c t i o n as shown.
22 58D6056 CSD V Se ries Direct V e nt Gas Sto ve Use proper gas type for the fireplace you are installing. If you have conflicting gas type, do not install fireplace.
58D6056 23 CSD V Se ries Direct V e nt Gas Sto ve The gas line connection may be made using 1/2" rigid tubing or an approved flex connector .
24 58D6056 CSD V Se ries Direct V e nt Gas Sto ve 1. Check gas type. The gas supply must be the same as stated on the appliance’s rating decal.
58D6056 25 CSD V Se ries Direct V e nt Gas Sto ve A remote wall switch and up to fifteen (15) feet of 18 Ga. wire may be used with this appliance. Attach the wall switch in a junction box at the desired location on the wall.
26 58D6056 CSD V Se ries Direct V e nt Gas Sto ve — This unit is supplied with ceramic fiber logs.
58D6056 27 CSD V Se ries Direct V e nt Gas Sto ve Figure 38 1. Carefully remove logs from wrapping. 2. Open front door of firebox. 3. Place rear log (#1) on rear log pin.
28 58D6056 CSD V Se ries Direct V e nt Gas Sto ve Figure 40 1. Carefully remove logs from wrapping. 2. Open front door of firebox.
58D6056 29 CSD V Se ries Direct V e nt Gas Sto ve This appliance is equipped with a pilot which must be lit by hand while following these instructions exactly . BEFORE OPERA TING smell all around the appliance area for gas.
30 58D6056 CSD V Se ries Direct V e nt Gas Sto ve .
58D6056 31 CSD V Se ries Direct V e nt Gas Sto ve O F F P I L O T O N PILOT FP1937 control knob on The “ON/OFF” switch for the main burner can be found on the back right side of the stove.
32 58D6056 CSD V Se ries Direct V e nt Gas Sto ve The venturi of the burner is equipped with an air shutter .
58D6056 33 CSD V Se ries Direct V e nt Gas Sto ve Make sure the gas valve knob is in the “OFF” position. W ait at least five (5) minutes before start-ing maintenance. A qualified agency should examine the venting system annually .
34 58D6056 CSD V Se ries Direct V e nt Gas Sto ve .
58D6056 35 CSD V Se ries Direct V e nt Gas Sto ve .
36 58D6056 CSD V Se ries Direct V e nt Gas Sto ve 18 19 20 17 3 4 13 12 15 16 5 2 8 9 1 6 10 14 1 1 7 586056 CSDV20 parts .
58D6056 37 CSD V Se ries Direct V e nt Gas Sto ve 1. Burner Assembly 1 58D0250 58D0250 2.
38 58D6056 CSD V Se ries Direct V e nt Gas Sto ve 18 19 20 21 22 17 3 4 13 12 16 5 1 1 2 15 1 14 6 10 8 7 9 586056 CSDV30 parts .
58D6056 39 CSD V Se ries Direct V e nt Gas Sto ve 1. Burner Assembly 1 58D0150 58D0150 2.
40 58D6056 CSD V Se ries Direct V e nt Gas Sto ve 22 23 16 24 25 26 28 4 5 14 13 7 6 2 3 2 17 20 18 19 8 1 1 15 9 10 12 21 586056 CSDV40 parts .
58D6056 41 CSD V Se ries Direct V e nt Gas Sto ve 1. Burner Assembly 1 58D0368 58D0368 2.
42 58D6056 CSD V Se ries Direct V e nt Gas Sto ve This product must be installed by a licensed plumber or gas fitter when installed within the Commonwealth of Massachusetts.
58D6056 43 CSD V Se ries Direct V e nt Gas Sto ve MHSC warrants its products to be free of defects in material and workmanship and backs each product with a Limited Lifetime W arranty . This warranty is to the original purchaser of a MHSC product and is not transferable.
149 Cleveland Drive • Paris, Kentucky 40361 www .mhsc.com.
An important point after buying a device Monessen Hearth CSDV30SLP (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Monessen Hearth CSDV30SLP yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Monessen Hearth CSDV30SLP - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Monessen Hearth CSDV30SLP you will learn all the available features of the product, as well as information on its operation. The information that you get Monessen Hearth CSDV30SLP will certainly help you make a decision on the purchase.
If you already are a holder of Monessen Hearth CSDV30SLP, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Monessen Hearth CSDV30SLP.
However, one of the most important roles played by the user manual is to help in solving problems with Monessen Hearth CSDV30SLP. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Monessen Hearth CSDV30SLP along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
