Instruction/ maintenance manual of the product PHP HWC-200 Premier
Go to page of 21
Premier Heat Pump s W ater Heater & Chiller User Manual.
Premier Heat Pumps – Water Heater and Chiller Manual Page 2 Essential Notes on Acceptance and Installation of the Premier Heat Pumps (PHP) Water Heater and Chiller 1) Delivery: After removing the trans port packaging please check the PHP Water Heater for any possible damage attributable to shipping.
Premier Heat Pumps – Water Heater and Chiller Manual Page 3 Content ESSENTIAL NOTES ON ACCEPTANCE AND INSTALLATION OF THE PREMIER HEAT PUMPS (PHP) WA TER HEATER AND CHILLER 2 Content 3 1 - Warnings .
Premier Heat Pumps – Water Heater and Chiller Manual Page 4 1 - Warnings and Cautions Incorrect handling has the potential to cause serious damage or injury to the unit, installer or operator.
Premier Heat Pumps – Water Heater and Chiller Manual Page 5 ! Caution ! Do not climb on the unit or try to move it once installed. Keep out of reach of children. Do not allow them to play on or near the unit. Do not place foreign objects or fingers into the air inlet/outlet.
Premier Heat Pumps – Water Heater and Chiller Manual Page 6 2 - Description of the Heat Pump 2-1 Outside 1 Power Plug 2 Control Panel 3 Air Inlet 4 Air Outlet 5 Temperature Sensor 6 Drainage 7 Cold .
Premier Heat Pumps – Water Heater and Chiller Manual Page 7 2-2 Inside 1 Control Panel Cover 15 Four-way Valve 2 29 Top Cover Plate 2 Control Panel 16 Gas Returning Pipe 30 Air Inlet Frame 3 Power P.
Premier Heat Pumps – Water Heater and Chiller Manual Page 8 2-3 Dimensional and Technical Characteristics Model Number PHP HWC-150 PHP HWC-200 PHP HWC-260 Heating Capacity (KW) 3.2 5.8 6.5 Cooling Capacity (KW) 2.6 4.9 5.7 Nominal Power Input (KW) 0.
Premier Heat Pumps – Water Heater and Chiller Manual Page 9 3 - Installation 3-1 Locating the Unit It is important to install the hot water heat pump in accordance with the following instructions. Water and electrical connec tions must be carried out by a suitably qualified tradesman or installer • The appliance must be installed outside.
Premier Heat Pumps – Water Heater and Chiller Manual Page 10 3-2 Water connections Please refer to the diagram below: 1) Connect the hot water in pipe (hot wa ter supply pipe) to t he outlet port on the hot water cylinder. Pay attention to heat preservation and ensure appropriate thermal insulation of the pipe work.
Premier Heat Pumps – Water Heater and Chiller Manual Page 11 3-3 Electrical Connections CAUTION: before connecting the appliance, make sure that the supply power line is disconnected from the network. General Power Supply Characteristics • Neutral mode TT and TN.
Premier Heat Pumps – Water Heater and Chiller Manual Page 12 3-4 How the reversible heat pump operates By using the free energy contained in the ambient air, the heat pump enables the heating of the water in a very ec onomical way.
Premier Heat Pumps – Water Heater and Chiller Manual Page 13 3-5 Display and Control Screen Description.
Premier Heat Pumps – Water Heater and Chiller Manual Page 14 4 - Use in Standard Mode Starting operation Press the power button when the unit has received the signal it gives out two 'beep' tones. The operation light switches on and the heat pump water heater starts operation.
Premier Heat Pumps – Water Heater and Chiller Manual Page 15 2) When it reaches the switch-off ti me, the heat pump water heater will automatically shut down. 3) Press the timer-on button again, and the set up is cancelled. 4) If the on/off button is pressed while t he unit is under the timer-off setting, the unit will shut down immediately.
Premier Heat Pumps – Water Heater and Chiller Manual Page 16 5 - Instructions for the Installer The installer must read the following and provide instructions to the purchaser.
Premier Heat Pumps – Water Heater and Chiller Manual Page 17 minutes. 2) Parameters for Exiting Defrost Mode: • When defrosting time reach 3 minutes and T4 reaches 10°C or defrosting time reaches 8 minutes, defrost ex its and starts heating water mode.
Premier Heat Pumps – Water Heater and Chiller Manual Page 18 7 - Gas Flow Diagram.
Premier Heat Pumps – Water Heater and Chiller Manual Page 19.
Premier Heat Pumps – Water Heater and Chiller Manual Page 20 8 - Wiring Diagram.
Premier Heat Pumps – Water Heater and Chiller Manual Page 21 9 - Problems and Solutions Please refer to the table below for the most common problems.
An important point after buying a device Premier PHP HWC-200 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Premier PHP HWC-200 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Premier PHP HWC-200 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Premier PHP HWC-200 you will learn all the available features of the product, as well as information on its operation. The information that you get Premier PHP HWC-200 will certainly help you make a decision on the purchase.
If you already are a holder of Premier PHP HWC-200, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Premier PHP HWC-200.
However, one of the most important roles played by the user manual is to help in solving problems with Premier PHP HWC-200. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Premier PHP HWC-200 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
