Instruction/ maintenance manual of the product 2547CE Vermont Casting
Go to page of 28
Encore Multi-Fuel Heater Model 2547CE Homeowner ’ s Installation and Operating Manual SAFETY NOTICE: IF THIS APPLIANCE IS NOT PROPERL Y INST ALLED, OPERA TED AND MAIN- T AINED, A HOUSE FIRE MA Y RESUL T . TO REDUCE THE RISK OF FIRE, FOLLOW THE INST ALLA TION INSTRUCTIONS.
2 Encore Multi-Fuel Heater 2000971 Congratulations on your choice of a V ermont Castings Encore Multi-Fuel Heater . With this purchase you have made a commitment to make the hearth a place of warmth, beauty , and comfort in your home. At CFM Corporation, we share that joy and appreciation for the hearth.
3 Encore Multi-Fuel Heater 2000971 Speciﬁcations 51 mm (2") 641 mm (25 ") T op exit flue collar height 686 mm (27") 657 mm (25 ") 470 mm (18 ") 187 mm (7 ") 686 mm (27") 572 mm (22 ") 394 mm (15 ") 127 mm (5") 73 mm (2 ") 600 mm (23 ") 133 mm (5 ") 381 mm (15") 610 mm (24") 83 mm (3 ") 686 mm (27") 543 mm (21 ") 457 mm (18") Encore MF 2547 dimensions 9/02 0971 Fig.
4 Encore Multi-Fuel Heater 2000971 SAFETY NOTICE: IF YOUR ENCORE IS NOT PROP- ERL Y INST ALLED, A HOUSE FIRE MA Y RESUL T . TO REDUCE THE RISK OF FIRE, FOLLOW THE INST ALLA TION INSTRUCTIONS. CONT ACT LOCAL BUILDING OR FIRE OFFICIALS ABOUT RESTRIC- TIONS AND INST ALLA TION INSPECTION REQUIRE- MENTS IN YOUR AREA.
5 Encore Multi-Fuel Heater 2000971 ST241 chimney types 12/13/99 djt ST241 A tile-lined masonry chimney A prefabricated double- wall insulated chimney Fig. 3 Approved chimney types. What Kind of Chimney to Use Y ou must connect the Encore Multi-Fuel to a code-ap- proved masonry chimney with a ﬂue liner , to a relined masonry chimney that meets local codes, or to a prefabricated metal chimney .
6 Encore Multi-Fuel Heater 2000971 sheet metal screws. The pre-drilled holes in the top of each section of chimney connector serve as guides when you drill 3 mm (1/8”) holes in the bottom of the next section. • Secure the chimney connector to the chimney .
7 Encore Multi-Fuel Heater 2000971 ST492 Defiant freestanding installation 1 1/00 Chimney Elbow Slip Pipe Standard Connector Oval to Round Adapter Flue Collar Thimble Flue Liner Flue ST492 Fig. 5 An exploded view of the chimney connection in a free- standing masonry installation.
8 Encore Multi-Fuel Heater 2000971 • The ﬁreplace damper must be sealed to prevent room air from escaping up the ﬂue. However , it must be possible to reopen the damper to inspect or clean the chimney . Through the Fireplace If your ﬁreplace opening height is at least 26 ¹⁄₂ " (675mm), you may install an Encore Multi-Fuel through the opening using a “positive connection” kit, available from your local dealer .
9 Encore Multi-Fuel Heater 2000971 ST247 Rear exit floor dgrm 12/14/99 djt Wood framing requires pro- tection from radiant heat ST247e Fig. 1 1 Combustible supporting timbers may lie beneath ﬁreplace hearths, reqireimg additional ﬂoor protection.
10 Encore Multi-Fuel Heater 2000971 in section 2 of Document J, all installations must comply with these requirements or with the relevant National or local building standards. Clearances to timber framed (studded) walls are in- cluded below . There are no speciﬁc minimum clearanc- es to solid noncombustible surfaces (e.
1 1 Encore Multi-Fuel Heater 2000971 Set Up Y our Stove Cast iron stoves are heavy , and it will take two to four people to move your Encore MF into position. W ash the protective coating of oil from the griddle with soap and water . Dry the griddle thoroughly and apply a light coating of vegetable oil to season the surface and help prevent rust.
12 Encore Multi-Fuel Heater 2000971 ST638 Encore damper control 2/01 Damper Positions Open (Updraft Mode) Closed (Bypass Mode) ST638 Fig. 20 The damper is either open or closed. There are no intermediate positions. Operation The Encore Multi-Fuel Controls T wo controls regulate the performance of the Encore: a primary air control supplies oxygen for the ﬁre, and a damper directs air ﬂow within the stove or directly up the vent.
13 Encore Multi-Fuel Heater 2000971 T wo W ays to Add Fuel The Encore’s griddle lifts for convenient top-loading of fuel, and is the easiest way to regularly add fuel. In addition, however , the front doors open for adding an occasional log to a ﬁre.
14 Encore Multi-Fuel Heater 2000971 on Page 17 to see how the size, type, and location of your chimney will affect your stove operation. When thermometer readings drop below 175° C (350° F) it’s time to adjust the air control for a higher burn rate or to reload the stove.
15 Encore Multi-Fuel Heater 2000971 up” a ﬁre. Keep all such liquids well away from the Encore while it is in use. 3. Light the newspaper and close the door . Gradually build up the ﬁre by adding a few 76-127 mm (3-5”) diameter splits. If this is one of the ﬁrst few “break- in” ﬁres, let the ﬁre burn brightly , and then let it die out.
16 Encore Multi-Fuel Heater 2000971 recommended only to add briquettes to the level of the front grate. 4. Close the damper . 5. When the surface temperature reaches 230° C (450° F), adjust the air control for the amount of heat you desire. NOTE: If the remaining coal bed is relatively thick and if wood fuel is well seasoned, it is possible to add fresh fuel (smaller pieces ﬁrst), close the door and damper , and reset the primary air thermostat for the desired heat output.
17 Encore Multi-Fuel Heater 2000971 A stove is part of a system, which includes the chimney , the operator , the fuel, and the home. The other parts of the system will affect how well the stove works. When there is a good match between all the parts, the system works well.
18 Encore Multi-Fuel Heater 2000971 Creosote Creosote is a by-product of slow wood-burning. It’s an organic tar that can condense in the ﬂue if it’s dense in the smoke, and slow-moving, and cools off to less than 143° C (290° F). Condensed creosote is volatile, and can generate chimney ﬁres if it gets hot enough.
19 Encore Multi-Fuel Heater 2000971 Maintenance Below you will ﬁnd important information on general care, inspection and maintenance of your V ermont Castings stove. Should it become necessary , use only replacement parts recommended by your authorized dealer Keep Y our Stove Looking New and Working Its Best Let the ﬁre in the stove go out and allow the stove to cool completely before beginning any maintenance procedure.
20 Encore Multi-Fuel Heater 2000971 ST642 Encore damper adjust 3/01 Damper Lock Nut Pressure Adjust - ing Screw ST642 Fig. 31 Adjusting the damper . ST641 Encore air shutter 3/01 Primary Air Shutter ST641 Fig. 30 The primary air shutter must move freely .
21 Encore Multi-Fuel Heater 2000971 ST531 Door Pawl 1 1/00 Pawl Small Locking Nut Large Lock- ing Nut Set Screw Handle Stub Striker Screw ST531 Fig. 32 T urn the door latch striker screw in or out to tighten or loosen the door latch. Replace the Stove Gaskets as Needed Y our Encore uses rope-type ﬁberglass gaskets to make a tight seal between some parts.
22 Encore Multi-Fuel Heater 2000971 Clean the chimney connector by disconnecting the sec- tions, taking them outside, and removing any deposits with a stiff wire brush. Reinstall the connector sections after cleaning, being sure to secure the joints between individual sections with sheet metal screws.
23 Encore Multi-Fuel Heater 2000971 1 3 2 4 5 6 7 8 9 12 9 19 14 15 16 17 18 20 21 22 24 25 27 28 29 31 32 33 34 35 46 47 48 49 36 37 38 39 40 41 42 43 44 45 50 53 54 58 56 55 61 60 33 13 13 57 59 57 10 10 62 0971 Encore MF parts 9/02 23 26 30 1 1 52 64 52 64 51 63 1 1 65 66 0971 CFM Corporation reserves the right to make changes in design, materials, speciﬁcations, prices and discontinue colors and products at any time, without notice.
24 Encore Multi-Fuel Heater 2000971 Encore Multi-Fuel Heater Model 2547CE (continued) Item Description Part Number Item Description Part Number 7. Griddle Handle Assembly 5004022 8. T op See Chart Pg. 28 9. Wedge (2) 1301810 10.
25 Encore Multi-Fuel Heater 2000971 Shell Enamel Parts - Encore Multi-Fuel Model 2547CE Part Name Classic Green Moonlight Sand Red Blue T op 1308618 2318618 2378618 1328618 2328618.
26 Encore Multi-Fuel Heater 2000971 .
27 Encore Multi-Fuel Heater 2000971 W arranty Limited 3 Y ear W arranty CFM Corporation warrants that this woodburning stove will be free of defects in material and workmanship for a period of three years from the date you receive it, except that the catalyst, thermostat assembly , handles, glass door panels, cement, and gasketing shall be warranted as described below .
410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 800-668-5323 • www .cfmcorp.com CFM Corporation .
An important point after buying a device Vermont Casting 2547CE (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Vermont Casting 2547CE yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Vermont Casting 2547CE - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Vermont Casting 2547CE you will learn all the available features of the product, as well as information on its operation. The information that you get Vermont Casting 2547CE will certainly help you make a decision on the purchase.
If you already are a holder of Vermont Casting 2547CE, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Vermont Casting 2547CE.
However, one of the most important roles played by the user manual is to help in solving problems with Vermont Casting 2547CE. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Vermont Casting 2547CE along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center