Instruction/ maintenance manual of the product Unvented Propane Gas Log Heater Model Split Oak and American Oak Design Desa
Go to page of 32
Save this manual for future reference. DESA INTERNA TIONAL UNVENTED (VENT -FREE) PROP ANE GAS LOG HEA TER ® Manually Control Models Also Designed Certified as V ented Decorative Appliance This appliance may be installed in an aftermarket* manufactured (mobile) home, where not prohibited by state or local codes.
2 103427 UNVENTED PROP ANE GAS LOG HEA TER SAFETY INFORMA TION DANGER: Carbon monoxide poisoning may lead to death! Carbon Monoxide Poisoning: Early signs of carbon monoxide poisoning re- semble the flu, with headaches, dizziness, or nausea. If you have these signs, the heater may not be working properly.
3 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS PRODUCT IDENTIFICA TION Figure 1 - Split Oak Design Model Left Front Branch Control Knob Rear Log Base Assembly Front .
4 103427 UNVENTED PROP ANE GAS LOG HEA TER DETERMINING AIR FLOW FOR HEATER LOCATION Determining if You Have a Confined or Unconfined Space Use this work sheet to determine if you have a confined or unconfined space.
5 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS AIR FOR COMBUSTION AND VENTILA TION Continued 4 . Compare the maximum Btu/Hr the space can support with the actual amount of Btu/Hr used.
6 103427 UNVENTED PROP ANE GAS LOG HEA TER NOTICE: Manual control heaters may be used as a vented product. If so, you must always run heater with chimney flue damper open. If running heater with damper open, non-combustible material above fireplace opening is not needed.
7 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS Heat Resistant Material (A) INST ALLA TION Continued Noncombustible Requirements for Material Distance (A) Safe Installation 12" or more Noncombustible material OK.
8 103427 UNVENTED PROP ANE GAS LOG HEA TER INSTALLING DAMPER CLAMP ACCESSORY FOR VENTED OPERATION Note: When used as a vented heater, appli- ance must be installed only in a solid-fuel burning fireplace with a working flue and constructed of non combustible material.
9 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS INST ALLA TION Continued INSTALLING HEATER BASE ASSEMBLY WARNING: If installing in a sunken fireplace, special care is needed. You must raise the fire- place floor to allow access to heater control panel.
10 103427 UNVENTED PROP ANE GAS LOG HEA TER Tee Joint Pipe Nipple Cap 3" Minimum Sediment Trap Gas Regulator From External Regulator (11" W.C.** to 14" W.C. Pressure) A.G.A. Design-Certified Manual Shutoff Valve With 1/8" NPT Tap* Approved Flexible Gas Hose (if allowed by local codes) CAUTION: Avoid damage to regulator.
11 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS INST ALLA TION Continued Pressure Testing gas Supply Piping system Test Pressures In Excess Of 1/2 PSIG 1. Disconnect heater and its individual manual shutoff valve from gas supply piping system.
12 103427 UNVENTED PROP ANE GAS LOG HEA TER Figure 22 - Installing Front Logs (#1L and #1R) Grate Prongs Metal Grate Bar Front Log (#1L) Notch Front Log (#1R) Right Front Branch (#5) Notches Left Fron.
13 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS INST ALLA TION Continued WARNING: Failure to posi- tion the parts in accordance with these diagrams or failure to use only parts specifically approved with this heater may result in property damage or personal in- jury.
14 103427 UNVENTED PROP ANE GAS LOG HEA TER Figure 28 - Pilot 8. T urn contr ol knob counterclockwise to desired hea ting level. The bur ners should light. Set control knob to any heat lev el between HI and LO. Thermocouple Ignitor Electrode Pilot Burner 1.
15 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS TO TURN OFF GAS TO APPLIANCE 1. Follow steps 1 thr ough 5 under Light- ing Instructions , page 14. 2. Depress contr ol knob and light pilot with match. 3. Keep contr ol knob pressed in f or 30 seconds after lighting pilot.
16 103427 UNVENTED PROP ANE GAS LOG HEA TER INSPECTING BURNERS Check pilot flame pattern and burner flame patterns often. PILOT FLAME PATTERN Figure 31 shows a correct pilot flame pat- tern. Figure 32 shows an incorrect pilot flame pattern. The incorrect pilot flame is not touching the thermocouple.
17 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS WARNING: If yellow tipping occurs, your heater could pro- duce increased levels of carbon monoxide. If front burner flame pattern shows yellow tipping, fol- low instructions at bottom of this page.
18 103427 UNVENTED PROP ANE GAS LOG HEA TER TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. WARNING: Turn off and un- plug heater and let cool before servicing. Only a qualified ser- vice person should service and repair heater.
19 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS TROUBLESHOOTING Continued OBSERVED PROBLEM One or both burners do not light after ODS/ pilot is lit Delayed ignition .
20 103427 UNVENTED PROP ANE GAS LOG HEA TER TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone.
21 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS OPTIONAL POSITIONING OF THERMOST A T SENSING BULB For Masonry and Factory- built Metal Fireplace If your log set cycl.
22 103427 UNVENTED PROP ANE GAS LOG HEA TER Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty.
23 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS LAVA ROCK - GA6060 For all models. Order when additional rock is desired. (3 lb. bag) DAMPER CLAMP - GA6080 For manually controlled models. Perma- nently opens chimney flue damper for vented operation.
24 103427 UNVENTED PROP ANE GAS LOG HEA TER ILLUSTRA TED PA R T S BREAKDOWN Variable Manually- Controlled Models 18 20 19 26 25 21 21 27 28 6 7 8 29 29 25 10 9 11 12 13 15 22 23 27-1 27-2 24 7-1 7-2 1.
25 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS P ARTS LIST Variable Manually-Controlled Models This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 22 of this manual.
26 103427 UNVENTED PROP ANE GAS LOG HEA TER 31 6 25 6 7 8 9 10 11 8 8 29 13 12 13 14 15 16 18 17 19 24 26 27 7-1 7-2 29 22 23 21 28 20 30 10-1 10-2 4 5 3 2 1R 1L ILLUSTRA TED PA R T S BREAKDOWN Thermo.
27 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS P ARTS LIST Thermostat-Controlled Split Oak Models This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 22 of this manual.
28 103427 UNVENTED PROP ANE GAS LOG HEA TER ILLUSTRA TED PA R T S BREAKDOWN Variable Manually-Controlled Models VL18PV VL24PV VL30PV 18 20 19 26 25 21 21 27 28 6 7 8 29 29 25 10 9 11 12 13 15 22 23 27.
29 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS P ARTS LIST Variable Manually-Controlled American Oak Models This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 22 of this manual.
30 103427 UNVENTED PROP ANE GAS LOG HEA TER NOTES _______________________________________________________________________________________________ ______________________________________________________.
31 103427 SPLIT OAK AND AMERICAN OAK DESIGN 18", 24" AND 30" MODELS NOTES _______________________________________________________________________________________________ _______________.
KEEP THIS WARRANTY W ARRANTY INFORMA TION Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard written warranty.
An important point after buying a device Desa Unvented Propane Gas Log Heater Model Split Oak and American Oak Design (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Desa Unvented Propane Gas Log Heater Model Split Oak and American Oak Design yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Desa Unvented Propane Gas Log Heater Model Split Oak and American Oak Design - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Desa Unvented Propane Gas Log Heater Model Split Oak and American Oak Design you will learn all the available features of the product, as well as information on its operation. The information that you get Desa Unvented Propane Gas Log Heater Model Split Oak and American Oak Design will certainly help you make a decision on the purchase.
If you already are a holder of Desa Unvented Propane Gas Log Heater Model Split Oak and American Oak Design, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Desa Unvented Propane Gas Log Heater Model Split Oak and American Oak Design.
However, one of the most important roles played by the user manual is to help in solving problems with Desa Unvented Propane Gas Log Heater Model Split Oak and American Oak Design. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Desa Unvented Propane Gas Log Heater Model Split Oak and American Oak Design along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
